DukeEnergyWritesDown

  • Subscribe to our RSS feed.
  • Twitter
  • StumbleUpon
  • Reddit
  • Facebook
  • Digg

Wednesday, 9 May 2012

Weak Link? Wind Turbine Step-Up Transformers

Posted on 15:35 by Unknown
The key wind turbine generator (WTG) step-up transformer design issues that wind farm owners and developers should pay attention to include transformer loading, harmonics and non-sinusoidal loads, transformer sizing and voltage variation and special requirements to withstand faults.  The role of the WTG step-up transformers is critical and its design must be carefully and thoughtfully analyzed and reevaluated.

Wind turbines are highly dependent upon local wind and other climatic conditions, and their yearly average load factors can be as low as 35 percent.

Harmonics and Non-Sinusoidal Loads

WTG transformers are switched with solid state controls to limit the inrush currents. While potentially aiding in the initial energization, these same electronic controls contribute damaging harmonic voltages that, when coupled with the non-sinusoidal wave forms from the turbines, cannot be ignored from a heating point of view.

Normal voltage is alternating at 60 cycles per second. If the transformer operates at other voltages, the voltage peaks will not line up and you will not get the amplification you would achieve when frequencies line up. The transformer tries to pass the voltage it sees through the circuit and causes extra loading. All the electronics used today send spikes on the line and each time a frequency disturbance goes back to the transformer, the transformer must be able to handle the higher loading it sees.

When a rectifier/chopper system (the electronic controller used in wind turbines) is used, the WTG transformer must be designed for harmonics similar to rectifier transformers. These are "dirty" from a harmonics point of view, meaning they may contain high frequencies that the wind farm owner does not want to pass onto the utility power's grid, because it will affect other equipment.

If this happens, it can result in a protective equipment fault, causing transmission grid equipment to protect itself against faults by shutting down. The WTG must be able to take the additional loading into consideration and provide electrostatic shields to prevent the transfer of harmonic frequencies between the primary and secondary windings. It must be able to handle the energy and not transmit it to the grid.

Cost Risk

When purchasing a WTG step-up transformer, make sure you factor in how reliability affects the total cost of ownership. Wind farm turbines are unique because they are ganged together and dependent upon each other. For example, say one transformer fails, with a loss of revenue of about $1,000 per day. It may take two or even three days to replace the transformer, and in the meantime, the faulty generator may take down 10 to 14 other generators, not allowing them to produce. So that loss of $1,000 of revenue could turn into $30,000 in lost revenue, plus the cost of another transformer, construction labor and crane expenses. (Power Engineering, April 2012)
Email ThisBlogThis!Share to XShare to FacebookShare to Pinterest
Posted in | No comments
Newer Post Older Post Home

0 comments:

Post a Comment

Subscribe to: Post Comments (Atom)

Popular Posts

  • Radon-222 Content In Natural Gas
    Fracking Opponents and Proponents Weigh In A debate is raging in the fracking area about the content of radioactive radon-222 in Marcellus ...
  • D.C. Water Management
    In 2004 the D.C. Water and Sewer Authority was forced to settle a federal lawsuit that claimed it failed for decades to stop its sewers from...
  • Sodium Sulfur Battery
    Sodium Sulfur (NaS) batteries are high capacity battery systems developed for electric power applications. A NaS battery consists of liquid...
  • White House Meets With Climate/Energy Stakeholders
    The White House with more than a dozen energy experts and industry officials last Thursday.  President Obama has pledged to focus aggressiv...
  • African American & Latino Energy Employment Program (ALEEP)
    The Center, through its outreach arm, the African American Environmentalist Association (AAEA), is implementing an African American & La...
  • (no title)
  • EPA & USDA Partner To Reduce Wasted Food
    Today, EPA and USDA announced the launch of a challenge that asks farmers, processors, manufacturers, retailers, communities and government...
  • EPA and Commerce Link Environmental Solutions Toolkit
    Offers Other Countries U.S. Approach to Specific Environmental Issues The U.S. Environmental Protection Agency (EPA) and the Department of C...
  • Carbon Dioxide Emissions Rose 1.4 Percent in 2012
    Global emissions of carbon dioxide from energy use rose 1.4 percent to 31.6 gigatons in 2012, setting a record and putting the planet on cou...
  • Mining Industry Wins Mountaintop Removal Court Ruling
    Mountaintop Removal U.S. District Judge Reggie B. Walton Tuesday threw out tougher water-quality standards issued by the Environmental Prote...

Blog Archive

  • ►  2013 (245)
    • ►  August (16)
    • ►  July (36)
    • ►  June (34)
    • ►  May (26)
    • ►  April (33)
    • ►  March (31)
    • ►  February (27)
    • ►  January (42)
  • ▼  2012 (255)
    • ►  December (33)
    • ►  November (49)
    • ►  October (11)
    • ►  September (36)
    • ►  August (31)
    • ►  July (30)
    • ►  June (39)
    • ▼  May (26)
      • United States Puts Tariffs on Chinese Wind Turbine...
      • No title
      • Pantex
      • Maryland & DC Water Bills To Double
      • EPA Regulations on Fracking Air Emissions
      • WIPP Can Supplement Or Replace Yucca Mountain
      • Obama Nominates Allison Mcfarlane To Chair NRC
      • Northwest Coal Exports
      • Costa Concordia Removal Plan Presented
      • EPA Carbon Standard Hearings For New Power Plants
      • NRC Chairman Gregory Jaczko Resigns
      • EPA Launches College Stormwater Management Competi...
      • Lisa Jackson Senate Appropriations 2013 Budget Tes...
      • Palm Oil Biofuels Under the Renewable Fuels Standard
      • EPA To Remove Vapor Capture Boot
      • Third Annual Industry Day at Cardozo Senior High S...
      • Microturbines
      • Weak Link? Wind Turbine Step-Up Transformers
      • The Air Rule Puzzle Continues
      • NRC Approves COLs for SCE&G, Santee Cooper Nuclear...
      • Chesapeake Energy Abuses Private Jet Travel?
      • David Hahn-Baker
      • In Reality, Keystone XL Pipeline Has Been Operatin...
      • Santa Catalina Island
      • Environmental Groups Target Coal Ash Disposal
      • EPA's Draft Guidance On Oil & Gas Hydraulic Fractu...
Powered by Blogger.

About Me

Unknown
View my complete profile